高频间歇梯度曝气启动短程硝化反硝化除磷颗粒污泥

徐贵达; 李冬; 刘志诚; 陶博; 张杰

PDF(986 KB)

中国环境科学 ›› 2021, Vol. 41 ›› Issue (11) : 5125-5132.

水污染与控制

高频间歇梯度曝气启动短程硝化反硝化除磷颗粒污泥

徐贵达¹, 李冬¹, 刘志诚¹, 陶博¹, 张杰^1,2

作者信息 +

High frequency intermittent gradient aeration initiation of short-cut nitrification and denitrification for phosphorus removal of granular sludge

XU Gui-da¹, LI Dong¹, LIU Zhi-cheng¹, TAO Bo¹, ZHANG Jie^1,2

Author information +

文章历史 +

摘要

反硝化除磷与厌氧氨氧化耦合可进一步降低脱氮除磷所需的碳源，而稳定获取NO₂^--N是两工艺独立、联合运行的关键.因此，以低C/N生活污水为研究对象，接种絮状污泥及少量长期贮存的好氧颗粒污泥，采用两段梯度曝气，并控制停曝时间（3min：3min），即以高频间歇梯度曝气模式，经60d的富集培养，将其诱导成具有短程硝化反硝化除磷功能的颗粒污泥，并分析了此过程中系统脱氮除磷性能变化.结果表明，稳定时期内，颗粒污泥平均粒径达841μm，SVI为31.23ml/g，颗粒结构致密，沉降性能良好.出水NO₃^--N小于0.1mg/L，TP<0.7mg/L，NO₂^--N>15mg/L，实现了P的高效去除和NO₃^--N的积累，并可为后续耦合Anammox提供稳定NO₂^--N基质.批次实验结果表明，颗粒中可利用NO₂^--N为电子受体的DPAOs占达57.63%，其富集提高了系统除磷能力.高频梯度间歇曝气可实现AOB与DPAOs的高度耦合，但仅以间歇曝气难以实现NOB的抑制，后通过在"氨谷点"前段，加入梯度曝气优化实际限氧曝气点，可强化对NOB的抑制，从而实现良好的亚硝酸盐积累.

Abstract

The coupling of denitrifying phosphorus removal and Anammox can further reduce the carbon source needed for nitrogen and phosphorus removal, and the stable production of NO₂^--N is the key to the independent and joint operation of the two processes. Therefore, with low C/N domestic sewage as the research object, flocculent sludge and a small amount of long-term stored aerobic granular sludge were inoculated in the reactor. The short-cut nitrification-denitrification-dephosphorization granular sludge was cultivated in 60 days by two-stage gradient aeration with the stop aeration time (3min:3min) controlled, and the system denitrification and dephosphorization performance was analyzed in this process. The results show that the average particle size of granular sludge is 841μm and the SVI is 31.23ml/g during the stable period. The particle structure is compact and the settling performance is good. The effluent NO₃^--N was less than 0.1mg/L, TP was less than 0.7mg/L, NO₂^--N was more than 15mg/L, which realized the efficient removal of P and accumulation of NO₂^--N, and could provide a stable NO₂^--N substrate for subsequent coupling of Anammox. The results of batch experiments showed that 57.63% of the DPAOs in the particles which could use NO₂^--N as electron acceptor, and the enrichment of DPAOs improved the phosphorus removal ability of the system. High-frequency intermittent gradient aeration can achieve a high coupling between AOB and DPAOS, but it is difficult to achieve NOB suppression only by intermittent aeration. Then, by adding gradient aeration in the front section of "ammonia trough point" to optimize the actual oxygen limiting aeration point, the inhibition of NOB can be enhanced, so as to achieve good accumulation of nitrite.

导出引用

徐贵达, 李冬, 刘志诚, 陶博, 张杰. 高频间歇梯度曝气启动短程硝化反硝化除磷颗粒污泥[J]. 中国环境科学. 2021, 41(11): 5125-5132

XU Gui-da, LI Dong, LIU Zhi-cheng, TAO Bo, ZHANG Jie. High frequency intermittent gradient aeration initiation of short-cut nitrification and denitrification for phosphorus removal of granular sludge[J]. China Environmental Science. 2021, 41(11): 5125-5132

中图分类号： X703

参考文献

[1] 吕亮.基于短程反硝化除磷的ABR-MBR工艺处理生活污水效能研究[D]. 苏州:苏州科技大学, 2017.Lü L. Study on the efficiency of ABR-MBR process treating domestic wastewater based on short-cut denitrifying phosphorous removal[D]. Suzhou:Suzhou University of Science and Technonogy, 2017.
[2] 刘煜,方茜,徐诗燕,等.同步亚硝化/反硝化除磷的调控因子及菌群分析[J]. 环境科学与技术, 2019,42(5):27-33.Liu Y, Fang Q, Xu S Y, et al. Control factors of simultaneous nitrification/denitrification phosphorus removal and analysis of flora[J]. Environmental Science & Technology, 2019,42(5):27-33
[3] Wang J, Qian F, Liu X, et al. Cultivation and characteristics of partial nitrification granular sludge in a sequencing batch reactor inoculated with heterotrophic granules[J]. Applied Microbiology and Biotechnology, 2016,100(21):9381-9391.
[4] Wang L, Zheng P, Chen T, et al. Performance of autotrophic nitrogen removal in the granular sludge bed reactor[J]. Bioresource Technology, 2012,123:78-85.
[5] Vázquez-Padín J, Mosquera-Corral A, Campos J L, et al. Microbial community distribution and activity dynamics of granular biomass in a CANON reactor[J]. Water Research, 2010,44(15):4359-4370.
[6] 李冬,刘博,王文琪,等.除磷颗粒诱导的同步短程硝化反硝化除磷颗粒污泥工艺[J]. 环境科学, 2020,41(2):867-875.Li D, Liu B, Wang W Q, et al. Simultaneous short-cut nitrification-denitrification phosphorus removal granules induced by phosphorus removal granules[J]. Environmental Science, 2020,41(2):867-875.
[7] Bournazou M N C, Hooshiar K, Arellano-Garcia H, et al. Model based optimization of the intermittent aeration profile for SBRs under partial nitrification[J]. Water Research, 2013,47(10):3399-3410.
[8] 李冬,郭跃洲,劳会妹,等.基于部分硝化的不同曝停频率下脱氮性能的比较[J]. 哈尔滨工业大学学报, 2019,51(8):8-13.Li D, Guo Y Z, Lao H M, et al. Comparison of nitrogen removal performances based on partial nitrification at different frequencies of alternating aerobic/anoxic[J]. Journal of Harbin Institute of Technology, 2019,51(8):8-13.
[9] 蒋轶锋,陈浚,王宝贞,等.间歇曝气对硝化菌生长动力学影响及NO₃^-积累机制[J]. 环境科学, 2009,30(1):85-90.Jiang T F, Chen J, Wang B Z, et al. Effect of intermittent aeration on growth kinetics of nitrifiers and mechanism for NO₂^- accumulation[J]. Environmental Science, 2009,30(1):85-90.
[10] 李冬,刘博,王文琪,等.污泥龄对除磷亚硝化颗粒系统的影响[J]. 环境科学, 2019,40(11):5048-5056.Li D, Liu B, Wang W Q, et al. Effects of solid retention time on the phosphorus removal and nitrosation granules system[J]. Environmental Science, 2019,40(11):5048-5056.
[11] Hu J Y, Ong S L, Ng W J, et al. A new method for characterizing denitrifying phosphorus removal bacteria by using three different types of electron acceptors[J]. Water Research, 2003,37(14):3463-3471.
[12] 邵兆伟.好氧颗粒污泥培养及短程硝化试验研究[D]. 兰州:兰州交通大学, 2019.Shao Z W. Study on culture and short-cut nitrification of aerobic granular sludge[D]. Lanzhou:Lanzhou Jiaotong University, 2019.
[13] Ogura S, Hamza R A, Tay J H. Dried aerobic granules for fast startup of aerobic granular sludge reactors:Reactivation and performance[J]. Journal of Water Process Engineering, 2020,36:101298.
[14] Pijuan M, Werner U, Yuan Z. Reducing the startup time of aerobic granular sludge reactors through seeding floccular sludge with crushed aerobic granules[J]. Water Research, 2011,45(16):5075-5083.
[15] 王维红,王燕杉,郑晓英,等.长时间低温储存好氧颗粒污泥的再生研究[J]. 水处理技术, 2020,46(10):33-38.Wang W H, Wang Y S, Zheng X Y, et al. Study on regeneration of aerobic granular sludge stored at low temperature for a long time[J]. Technology of Water Treatment, 2020,46(10):33-38.
[16] Zhang Q, Hu J, Lee D. Aerobic granular processes:Current research trends[J]. Bioresource Technology, 2016,210:74-80.
[17] Liu Y, Tay J. Characteristics and stability of aerobic granules cultivated with different starvation time[J]. Applied Microbiology and Biotechnology, 2007,75(1):205-210.
[18] Gao D, Liu L, Liang H, et al. Aerobic granular sludge:Characterization, mechanism of granulation and application to wastewater treatment[J]. Critical Reviews in Biotechnology, 2011, 31(2):137-152.
[19] Mcswain B S, Irvine R L, Wilderer P A. The influence of settling time on the formation of aerobic granules[J]. Water science and technology, 2004,50(10):195-202.
[20] Laspidou C S, Rittmann B E. A unified theory for extracellular polymeric substances, soluble microbial products, and active and inert biomass[J]. Water Research, 2002,36(11):2711-2720.
[21] He Q, Chen L, Zhang S, et al. Simultaneous nitrification, denitrification and phosphorus removal in aerobic granular sequencing batch reactors with high aeration intensity:Impact of aeration time[J]. Bioresource Technology, 2018,263:214-222.
[22] 张杰,劳会妹,李冬,等.高频曝停下停曝时间对亚硝化颗粒污泥性能的影响[J]. 环境科学, 2020,41(1):360-367.Zhang J, Lao H M, Li D, et al. Effect of on/off aeration time ratio under high frequency on/off aeration on performance of nitrosated granular sludge[J]. Environmental Science, 2020,41(1):360-367.
[23] Seviour T, Yuan Z, van Loosdrecht M C M, et al. Aerobic sludge granulation:A tale of two polysaccharides?[J]. Water Research, 2012,46(15):4803-4813.
[24] Tay J H, Liu Q S, Liu Y. The role of cellular polysaccharides in the formation and stability of aerobic granules[J]. Letters in applied microbiology, 2001,33(3):222-226.
[25] Laspidou C S, Rittmann B E. A unified theory for extracellular polymeric substances, soluble microbial products, and active and inert biomass[J]. Water Research, 2002,36(11):2711-2720.
[26] Xiong Y, Liu Y. Importance of extracellular proteins in maintaining structural integrity of aerobic granules[J]. Colloids and Surfaces B:Biointerfaces, 2013,112:435-440.
[27] Li D, Lv Y, Zeng H, et al. Startup and long term operation of enhanced biological phosphorus removal in continuous-flow reactor with granules[J]. Bioresource Technology, 2016,212:92-99.
[28] Lackner S, Gilbert E M, Vlaeminck S E, et al. Full-scale partial nitritation/anammox experiences-An application survey[J]. Water Research, 2014,55:292-303.
[29] Gilbert E M, Agrawal S, Brunner F, et al. Response of different nitrospira species to anoxic periods depends on operational DO[J]. Environmental Science & Technology, 2014,48(5):2934-2941.
[30] 阳素攀,方茜,林曼婷,等.同时硝化/反硝化除磷工艺的脱氮除磷效能[J]. 环境科学与技术, 2012,35(6):106-109.Yang S P, Fang Q, Lin M T, et al. Performance of simultaneous nitrification/denitrifying phosphorus removal process[J]. Environmen-tal Science & Technology, 2012,35(6):106-109.
[31] 李寒.同步硝化反硝化与反硝化除磷耦合强化脱氮除磷微生物特性研究[D]. 南京:东南大学, 2017.Li H. Study of nitrogen and phosphorus removal and microbial character on the combination of simultaneous Nitrification/Denitrification and Denitrifying phosphorus removal[D]. Nanjing:SoutheastUniversity, 2017.
[32] Glass C, Silverstein J. Denitrification kinetics of high nitrate concentration water:pH effect on inhibition and nitrite accumulation[J]. Water Research, 1998,32(3):831-839.